Amateur-built VARI EZE N944X accident near Santa Monica, California

Probable cause

An undetected fluid leak in the right brake line, which resulted in a reduction of braking effectiveness at the right wheel and a loss of directional control during the landing roll.

NTSB analysis

The private pilot reported that, during the landing roll, the experimental amateur-built airplane experienced a partial loss of right brake effectiveness. The pilot attempted to counter the directional control imbalance as the roll continued, but he became concerned that the airplane might run off the end of the runway and the drop-off at the end, so he applied maximum brake pressure. The airplane then veered left, departed the runway, and impacted a hangar.

Postaccident examination revealed that a slow fluid leak had developed at the inlet fitting of the right brake caliper, and the fluid level in the reservoir for the right brake master cylinder had dropped to just under half of its capacity. This leak most likely allowed air to be introduced into the system either through the fitting or the depleted brake reservoir, which resulted in reduced effectiveness of the right brake. Maintenance records indicated that the pilot replaced the hydraulic lines on the right side about 147 flight hours before the accident.

The airplane was equipped with a free-castering nosewheel and ground steering was accomplished through differential braking once rudder effectiveness diminished at lower speeds. Therefore, with the loss of braking effectiveness on one side, the pilot had limited means to effectively slow the airplane and maintain directional control once the airplane decelerated to a speed below which rudder authority was available.

Text from the NTSB. Open the NTSB docket for WPR18LA089 for the full record.